If you wish to contribute or participate in the discussions about articles you are invited to join SKYbrary as a registered user
A343, Toronto Canada, 2005
From SKYbrary Wiki
Revision as of 22:26, 6 December 2018 by Integrator3
|On 2 August 2005, an Air France Airbus A340 attempted a daylight landing at destination on a rain-soaked runway during an active thunderstorm and overran for 300 metres ending up in a ravine from where, despite its destruction by fire, all occupants escaped. The Investigation recommendations focussed mainly on crew decision making in adverse weather conditions and issues related to the consequences of such an overrun on survivability.|
|Actual or Potential
|Fire Smoke and Fumes, Human Factors, Runway Excursion, Weather|
|Type of Flight||Public Transport (Passenger)|
|Origin||Paris/Charles de Gaulle Airport|
|Intended Destination||Toronto/Lester B. Pearson International Airport|
|Take off Commenced||Yes|
|Location - Airport|
|Airport||Toronto/Lester B. Pearson International Airport|
|Tag(s)||Inadequate Aircraft Operator Procedures|
|Tag(s)||Post Crash Fire|
|Tag(s)||Inappropriate crew response - skills deficiency,|
Procedural non compliance,
|Tag(s)||Overrun on Landing,|
Excess Water Depth"Excess Water Depth" is not in the list (Overrun on Landing, Directional Control, Excessive Airspeed, RTO decision after V1, High Speed RTO (V above 80 but not above V1), Unable to rotate at VR, Collision Avoidance Action, Late Touchdown, Significant Tailwind Component, Significant Crosswind Component, ...) of allowed values for the "RE" property.,
Significant Tailwind Component
Strong Surface Winds
|Tag(s)||Evacuation slides deployed|
Evacuation on Cabin Crew initiative
|Damage or injury||Yes|
|Aircraft damage||Hull loss|
|Causal Factor Group(s)|
On 2 August 2005, an Airbus A340-300 being operated by Air France on a scheduled passenger flight from Paris CDG to Toronto landed at destination in daylight during a thunderstorm and failed to stop before reaching the end of the runway. It exited the airport perimeter and crossed a main road before ending up in a ravine approximately 300 m984.252 ft <br /> beyond the end of the runway. Although an intense post-crash fire began immediately and smoke began to enter the cabin, all 309 occupants were able to evacuate before the fire took significant hold. The fire eventually consumed most of the upper fuselage, the adjacent wing sections and the vertical stabilizer.
An Investigation into the Accident was carried out by the Canadian Transportation Safety Board (TSB). It was established that all aircraft systems had been serviceable and working as designed throughout the approach and landing and that, therefore, no mechanical malfunction contributed to the accident outcome.
It was established that the First Officer had been designated Pilot Flying (PF) for the approach and landing. It was noted that forecast weather for the arrival had included the possibility of thunderstorm activity at both destination and alternates and that the flight crew had been aware of weather-related delays for their arrival and that other aircraft were having to divert because of them. It was found that the approach briefing had not included any reference to either runway length or the missed approach procedure and no runway distance calculations for a wet or contaminated runway were included.
When the aircraft was on short finals, it was evident that an active thunderstorm was in the vicinity of the airport and the previous landing aircraft reported that braking action was poor. FDR data showed that after the PF had disconnected the autopilot at 323 feet (above ground level), the aircraft had begun to deviate above the ILS GS. It crossed the runway threshold still high and, as the flare was commenced, it entered heavy rain which reduced visual reference - recorded visibility just after the accident was 2000 m6,561.68 ft <br />. Numerous lightning strikes were occurring, particularly at the far end of the runway. The aircraft did not touch down until it was 3800 ft1,158.24 m <br /> from the beginning of the 9000 ft2,743.2 m <br /> runway and did so with the right main landing gear slightly left of the runway centerline and the aircraft axis about six degrees to the right of it. Autobrake had been set to Medium, but the crew immediately applied maximum manual braking and attempted to align the aircraft with the centreline. FDR data showed that Idle reverse was selected 12.8 seconds after main gear touchdown and full reverse 3.6 seconds later. There were no standard callouts for spoiler and reverser deployment from the aircraft commander. The aircraft was not able to stop on the remaining runway and overran the end at a groundspeed of approximately 80 kts148.16 km/h <br />41.12 m/s <br /> It was concluded that there was no information to indicate that the aircraft had encountered windshear during its approach and landing.
The Investigation considered that:
"The point at which the situation changed from normal and manageable to abnormal and critical was near the runway threshold when the aircraft entered the perimeter of the cell activity. At this time, a number of circumstances combined, leading directly to the accident. The PF was monitoring the airspeed trend vector and responded to an indication of decreasing airspeed by adding power; however, he kept it there too long. Had the autothrust been engaged, the engine power would have been adjusted to maintain the proper airspeed, and it would have been more likely that the aircraft would have been landed closer to the target touchdown point. At that very time, both pilots became preoccupied with the reduced forward visibility, and airspeed scanning rate decreased. Without the airspeed control provided through the autothrust, the increase in energy from the extra thrust increased the airspeed and groundspeed. As they crossed the runway threshold, with the heavy rain, low visibility, lightning, and shifting winds, the flight crew members became overwhelmed by the severe weather conditions and became task saturated, making a normal landing difficult… While they were in the flare and the initial float, the pilots did not appreciate how much of the runway was being used up… The delay in the selection of the thrust reversers and the subsequent delay in the application of full reverse thrust added to the landing distance needed.”
It was noted that whilst the surface water on the runway reduced the braking action available, calculations during the Investigation had shown that the aircraft could not have stopped in the runway distance remaining after the late touchdown even if the runway had been wet instead of contaminated. Given that the flight crew had “observed the runway to be shiny, like the surface of a lake” which suggested that there would probably be more than 3 mm of water on the runway it was considered that they “either did not take this into account… when they continued with the approach and landing, although they knew that the crosswind exceeded (the allowable limit for contaminated runways).
It was also noted that "Air France Airbus A340 crews have the option of conducting a go-around during an approach when it becomes evident that it is unsafe to land. In theory, the decision to go around can be made as late as when the aircraft is on the ground, as long as reversers are not yet selected.” However it was considered that “when the aircraft was near the threshold… the crew members became committed to landing and believed that their option to go around no longer existed”.
The non use of available rain repellent was considered by the Investigation. The flight crew had been unaware of this capability and ”a survey among other pilots flying aircraft that have this system revealed that many of them either do not use or do not know under what conditions it would be advantageous to use it.”
The fact that under Air France SOPs the decision on whether to initiate a go-around, missed approach or a balked landing could at the time be made only by the Captain, regardless of who is flying the aircraft, was noted and it was considered by the Investigation that “having more than one pilot responsible for making the call about a missed approach can increase the likelihood that an unsafe condition will be recognized early and decrease the time it might otherwise take to initiate the missed approach”.
In respect of the evacuation, it was noted that:
- the speed of the evacuation was impeded because “nearly 50 per cent of the passengers retrieved carry-on baggage”;
- a minority of passengers did not understand either French or English, the only languages used on the Safety Cards;
- all the slides used were dual lane slides but none were used in a way that would be likely to have met the certification flow rates;
- when donned, smoke hoods available to the cabin crew caused their speech to be inaudible; a megaphone would have been required to achieve this but these were not readily available at smoke hood positions.
The investigation considered the question of the limited Runway End Safety Area which had existed at the end of the accident runway and the opportunities which were available and which could have reduced the potential consequences of an overrun such as the one which occurred. It was noted that had the Runway 24L RESA met either the ICAO Recommended Practice, US FAA standard or the FAA alternate means of compliance Engineered Materials Arresting System, both aircraft damage and occupant injuries may have been reduced. The effect of these alternatives in respect of the overrun are illustrated on the diagram below taken from the official report:
The Findings of the Investigation included the following:
- The crew conducted an approach and landing in the midst of a severe and rapidly changing thunderstorm. There were no procedures within Air France related to distance required from thunderstorms during approaches and landing, nor were these required by regulations.
- The touchdown was long because the aircraft floated due to its excess speed over the threshold and because the intense rain and lightning made visual contact with the runway very difficult.
- Although the area up to 150 m492.126 ft <br /> beyond the end of Runway 24L was compliant with the (applicable State Guidance Material, Transport Canada’s) Aerodrome Standards and Recommended Practices (TP 312E), the topography of the terrain beyond this point, along the extended runway centreline, contributed to aircraft damage and to the injuries to crew and passengers.
A number of Safety Actions were taken by Air France, Transport Canada and Airbus in response to the findings of the Investigation.
A total of 7 Safety Recommendations were made as a result of the Investigation as follows:
- The Department of Transport establish clear standards limiting approaches and landings in convective weather for all air transport operators at Canadian airports.
- France’s Direction Générale de l'Aviation Civile and other civil aviation authorities establish clear standards limiting approaches and landings in convective weather.
- The Department of Transport mandate training for all pilots involved in Canadian air transport operations to better enable them to make landing decisions in deteriorating weather.
- France’s Direction Générale de l'Aviation Civile and other civil aviation authorities mandate training for air transport pilots to better enable them to make landing decisions in deteriorating weather.
- The Department of Transport and other civil aviation authorities require crews to establish the margin of error between landing distance available and landing distance required before conducting an approach into deteriorating weather.
- The Department of Transport require all Code 4 runways to have a 300 m984.252 ft <br /> Runway End Safety Area (RESA) or a means of stopping aircraft that provides an equivalent level of safety.
- The Department of Transport require that passenger safety briefings include clear direction to leave all carry-on baggage behind during an evacuation.
- Cumulonimbus (Cb)
- Landing Performance
- Landing on Contaminated Runways
- Cross Wind Landings
- Missed Approach
- Runway End Safety Area (RESA)
- Runway Excursion
- Passenger Cabin Fire
- Transportation Safety Board of Canada, Aviation Investigation Report - A05H0002.
- The “Barn Door” Effect by C. West, Ph.D., NOAA - a paper about pilots’ propensity to continue approaches to land when closer to convective weather than they would wish to get while en route.